Advantech COMPACTPCI CP-150 Manuel d'utilisateur

Advantech CompactPCI™ CP-150 6U-6-slot backplane portable enclosure for CompactPCI™ Modular Industrial Computer

CP-150 User Manual --- Page 11 General Information

CP-150 User Manual --- Page 21.1 Introduction CP-150 is a robust, portable enclosure with 15” touch LCD monitor. With a field-tested rugged, high i

CP-150 User Manual --- Page 31.2 Features • Portable enclosure for 6U CompactPCI® boards • 6-slot 6U CompactPCI® backplane • 15” Touch LCD monitor

CP-150 User Manual --- Page 4Factor Correction). • Output (per module): 400W, +3.3V,and +5V total output power shall not exceed 180W • Maximum load:

CP-150 User Manual --- Page 52 Installation

CP-150 User Manual --- Page 62.1 Initial Inspection We have carefully inspected the CP-150 mechanically and electrically before shipping. It should

CP-150 User Manual --- Page 7 Figure 2-2: Right view of Cp-150 2.3 Computer Operation 2.3.1 Keyboard and Touch Pad How to release There are two rel

CP-150 User Manual --- Page 8How to pack away the keyboard Follow the same procedure to pack the keyboard back into the portable enclosure in a reve

CP-150 User Manual --- Page 9the left/right buttons on a mouse. You may also tap on the touch pad to indicate a left click. 2.3.2 Side Panel Depend

CP-150 User Manual --- Page 10 Figure 2-6 2.3.4 Power Supply The CP-150 comes with a PS/2 power supply with full-range auto-sensing Active PFC, and

CP-150 User Manual --- Page IICopyright Notice This document is copyrighted, 2004. All rights are reserved. The original manufacturer reserves the r

CP-150 User Manual --- Page 112.3.6 Additional Bottom Cooling Fan An additional cooling fan can be found on the bottom of the case. This bottom fan

CP-150 User Manual --- Page 12computer stores and are usually ready for use if pre-formatted. You may insert the disk into the drive with the disk f

CP-150 User Manual --- Page 13 Figure 2-9 2.3.10 Removable Cooling Fan The cooling fan on the right side can be easily removed. You don’t need to ta

CP-150 User Manual --- Page 14slot is marked by a triangle around the slot number (1). Please refer to the backplane user's manual. The insert/

CP-150 User Manual --- Page 152.4.3 Installing a 3.5” Hard Disk Drive Follow this procedure to install 3.5" hard disk drives in the CP-150: 1.

CP-150 User Manual --- Page 16Unscrew the upper cover of slot unit Unscrew Unscrew

CP-150 User Manual --- Page 17Pull the slot unit away Figure 2-12 2.4.5 Remove Drive Bay The whole 6U PXI slot unit Figure 2-13

CP-150 User Manual --- Page 18Unscrew the fixed cover Figure 2-14 Unscrew the CD-ROM Unscrew Figure 2-15

CP-150 User Manual --- Page 19Remove the CD-ROM Figure 2-16 Unscrew the FDD Unscrew

CP-150 User Manual --- Page 20Remove the FDD Figure 2-18 2.4.6 Remove the side-cooling fan Unscrew the cooling f

CP-150 User Manual --- Page IIIProduct warranty Advantech warrants to you, the original purchaser, that each of its products will be free from defec

CP-150 User Manual --- Page 21Remove the cooling fan Figure 2-20 2.4.7 Remove the Power Supply Unscrew &am

CP-150 User Manual --- Page 22Remove the power supply with cover Figure 2-22

CP-150 User Manual --- Page 233 Backplane

CP-150 User Manual --- Page 243.1 General Information The backplane designed for the CP-150 is the MIC-3800. MIC-3800 has an H.110 CT bus and six Co

CP-150 User Manual --- Page 25the peripheral slots have logical numbers 2~5. The connectors in logical slot 1 are designated as 1-P1, 1-P2, and 1-P3

CP-150 User Manual --- Page 26CN8CN6CN112System slotID=AD313456ID=AD30 ID=AD29 ID=AD28 ID=AD27 Figure 3-1: MIC-3800 Backplane slot numbering 3.5 Co

CP-150 User Manual --- Page 27CN2CN12CN7CN13CN9CN11CN10ATX1JP1JP2JP3JP4JP5JP6JP9JP10 Figure 3-2: The connector and jumper locations on the rear side

CP-150 User Manual --- Page 28 Appendix A Pin Assignments

CP-150 User Manual --- Page 29A.1 MIC-3800 System Slot P1 Connector Table A-1: MIC-3800 system slot P1 connector Pin Z A B C D E F 25 GND +5

CP-150 User Manual --- Page 30A.2 MIC-3800 System Slot P2 Connector Table A-2: MIC-3800 system slot P2 connector Pin Z A B C D E F 22 GND GA4 GA3

CP-150 User Manual --- Page IVImportant Safety Information SAFETY INSTRUCTIONS 1. Please read these safety instructions carefully. 2. Please keep

CP-150 User Manual --- Page 31A.3 MIC-3800 System Slots P3 Connector Table A-3: MIC-3800 system slot P3 connector Pin Z A B C D E F 19 GND N/C

CP-150 User Manual --- Page 32A.4 MIC-3800 System Slot P4 Connector Table A-4: MIC-3800 system slot P4 connector Pin Z A B C D E F 25 GND N/C N/C N/

CP-150 User Manual --- Page 33A.5 MIC-3800 System Slot P5 Connector Table A-5: MIC-3800 system slot P5 connector Pin Z A B C D E F 22 GND N/C

CP-150 User Manual --- Page 34A.6 MIC-3800 Peripheral Slot P1 Connector Table A-6: MIC-3800 peripheral slot P1 connector Pin Z A B C D E F 25

CP-150 User Manual --- Page 35A.7 MIC-3800 Peripheral Slot P2 Connector Table A-7: MIC-3800 peripheral slot P2 connector Pin Z A B C D E F 22 GND G

CP-150 User Manual --- Page 36A.8 MIC-3800 Peripheral Slot P3 Connector Table A-8: MIC-3800 peripheral slot P3 connector Pin Z A B C D E F 19 GND N/

CP-150 User Manual --- Page 37A.9 MIC-3800 Peripheral Slot P4 Connector Table A-9: MIC-3800 peripheral slot P4 connector Pin Z A B C D E F 25

CP-150 User Manual --- Page 38A.10 MIC-3800 Peripheral Slot P5 Connector Table A-10: MIC-3800 peripheral slot P5 connector Pin Z A B C D E F 19 GND

CP-150 User Manual --- Page 39A.11 ATX Power Connector (ATX1) 111 2010 Table A-11: ATX Power Connector Pin Signal Pin Signal 1 +3.3V 11 +3.3V 2 +3

CP-150 User Manual --- Page 40A.12 IDE Interface Connectors (CN8,CN12) Table A-12: IDE Interface Connectors Pin Signal Pin Signal 1 RESET# 21 DMREQ

CP-150 User Manual --- Page V16. Never open the equipment. For safety reason, qualified service personnel should only open the equipment. 17. CAUTIO

CP-150 User Manual --- Page 41A.13 FDD Interface connector (CN6) Table A-13: FDD Interface Connector Pin Signal Pin Signal 1 +5V 14 STEP# 2 INDEX# 1

CP-150 User Manual --- Page 42A.15 KEYBOARD Interface Connector (CN11) Table A-15: KEYBOARD Interface Connector Pin Signal 1 KBCLK 2 KBDATA 3 N/C 4

CP-150 User Manual --- Page 43A.18 USB Interface connector (CN7) Table A-18: USB Interface Connector Pin Signal 1 USBVCC 2 D0- 3 D0+ 4 GND 5 N/C 6 N

CP-150 User Manual --- Page 44 Appendix B Ordering Information

CP-150 User Manual --- Page 45 • CP-150: CompactPCI™ portable enclosure with 6-slot H.110 CT backplane (MIC-3800), cooling fan modules, and 400W ATX

CP-150 User Manual --- Page VIPacking List Before installation, ensure that the following materials have been received: • One CP-150 CompactPCI™ enc

CP-150 User Manual --- Page VIIContents 1. General Information... 1 1.1 Introduction ...

CP-150 User Manual --- Page VIII3.5 Connector and jumper locations.....24 3.5.1 ATX Power Connect

CP-150 User Manual --- Page IXFigures Figure 1-1: CP-150 dimensions ....................4